ApplianceJunk.com

Forum Index => Refrigerator & Freezer Repair => Topic started by: AJ on August 02, 2007, 12:26:21 PM

Title: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: AJ on August 02, 2007, 12:26:21 PM
This video shows you a complete ice maker cycle in real time. You can put the ice maker into a test mode to make your ice maker run as shown in the video clip.

IMPORTANT NOTE: For no ice or low ice production, always confirm normal (0-5 Deg F) freezer temperatures before beginning diagnostic checks. The ice maker is designed not to run if the freezer in  not in this temperature range.


In this test mode the ice make will go through the harvest, testing the heater. You will also know if the ice maker motor is working by putting the ice maker though this test cycle.

With the ice maker in test mode it will also run the water fill cycle. This will tell you if the water valve (http://appliancejunk.com/forums/index.php?topic=51.0) is working and if the water line is frozen or open.

If you find the water fill tube that goes to the ice maker is frozen you will have to thaw it out.
If you have to keep thawing the fill tube out then you will want to install a [url=http://click.linksynergy.com/fs-bin/click?id=omv7WULuxaw&offerid=92089.532216931&type=10&subid=]Fill Tube and Heater Kit [/url]icon .

It is very simple to get the ice maker into this test mode. there are only a few steps you have to take.

Note: The optics must be working properly (in-door ice makers only) to test the ice maker.

Important: If the freezer temperature is not cold enough to allow the ice maker bi-metal to close, a jumper must be installed on the ice maker at the test points T and H, and the test rerun.

1. Run an optics (http://appliancejunk.com/forums/index.php?topic=44.0) check (in-door ice makers only)

2. Disconnect power to the unit.

3. Slide the ice maker out of the mounting rails and leave the wiring harness connected.

4. Jumper the thermostat, as shown below. You can not leave it this way or your ice make could flood your house. You only jumper the thermostat for testing!


(http://appliancejunk.com/forums/gallery/1_02_08_07_3_12_43.JPG)


(http://appliancejunk.com/forums/gallery/1_02_08_07_10_39_32.JPG)


5. Remount the ice maker, making sure that the water fill tube is inside the fill cup.

6. Connect power to the unit.

7. Make sure there is a clear path across the bin for the infrared beam to travel to the receiver sensor. (in-door ice makers only)

8. Close the freezer door and wait 5 seconds to allow the optics relay to close.

9. Open the freezer door and you will see the ejector bar moving. Remove the thermostat jumper prior to the ejector blades reaching the 10:00 position, or else you will not see the water fill. The mold should be warm due to the heater operation.

10. Disconnect the power immediately after the water fill. If the ice make will not fill with water Check the Water Valve (http://appliancejunk.com/forums/index.php?topic=51.0) to make sure it is working.

11. With the freezer door closed, reconnect the power.

12. Wait for a minimum of 5 seconds, and a maximum of 50 seconds, then open the freezer door, and view the status of the LED for the output codes.


4322658A R-92 Whirlpool and KitchenAid Indoor Ice System - Ice Maker Service Repair Manual (http://appliancejunk.com/forums/index.php?action=downloads;sa=view;down=43)



WHIRLPOOL Complete Icemaker Assembly (8 Cube), part number: AP3182733 (http://click.linksynergy.com/fs-bin/click?id=omv7WULuxaw&subid=0&offerid=225193.1&type=10&tmpid=2111&RD_PARM0=http%253A%252F%252Fwww.appliancepartspros.com%252FAppliance-Parts%252Fwhirlpool-complete-icemaker-assembly--8-cube--item-number-ap3182733.aspx&RD_PARM1=http&RD_PARM2=%253A%252F%252Fwww.appliancepartspros&RD_PARM3=.com%252FAppliance-Parts%252Fwhirlpool-complete-icemaker-assembly--8-cube--item-number-ap3182733.aspx)


This icemaker is for 25-27 cubic feet models that have vertical auger dispenser installed in the freezer door. 8 cube icemaker.

(http://appliancejunk.com/images/ordernow.gif) (http://click.linksynergy.com/fs-bin/click?id=omv7WULuxaw&subid=0&offerid=225193.1&type=10&tmpid=2111&RD_PARM0=http%253A%252F%252Fwww.appliancepartspros.com%252FAppliance-Parts%252Fwhirlpool-complete-icemaker-assembly--8-cube--item-number-ap3182733.aspx&RD_PARM1=http&RD_PARM2=%253A%252F%252Fwww.appliancepartspros&RD_PARM3=.com%252FAppliance-Parts%252Fwhirlpool-complete-icemaker-assembly--8-cube--item-number-ap3182733.aspx)
(http://www.appliancepartspros.com/partpic/Z3BqLjBfbXNfNzk1ODkxMi9MUFcvc290b2hwdHJhcC8%3d.jpg) (http://click.linksynergy.com/fs-bin/click?id=omv7WULuxaw&subid=0&offerid=225193.1&type=10&tmpid=2111&RD_PARM0=http%253A%252F%252Fwww.appliancepartspros.com%252FAppliance-Parts%252Fwhirlpool-complete-icemaker-assembly--8-cube--item-number-ap3182733.aspx&RD_PARM1=http&RD_PARM2=%253A%252F%252Fwww.appliancepartspros&RD_PARM3=.com%252FAppliance-Parts%252Fwhirlpool-complete-icemaker-assembly--8-cube--item-number-ap3182733.aspx)



WHIRLPOOL 4389102 (http://click.linksynergy.com/fs-bin/click?id=omv7WULuxaw&subid=0&offerid=225193.1&type=10&tmpid=2111&RD_PARM0=http%253A%252F%252Fwww.appliancepartspros.com%252FAppliance-Parts%252Fwhirlpool-refrigerator-p-c--board-kit-item-number-ap3137510.aspx%253Fpn_%253D4389102&RD_PARM1=http&RD_PARM2=%253A%252F%252Fwww.appliancepartspros&RD_PARM3=.com%252FAppliance-Parts%252Fwhirlpool-refrigerator-p-c--board-kit-item-number-ap3137510.aspx%253Fpn_%253D4389102) Refrigerator P.c. Board Kit, AP3137510 (http://click.linksynergy.com/fs-bin/click?id=omv7WULuxaw&subid=0&offerid=225193.1&type=10&tmpid=2111&RD_PARM0=http%253A%252F%252Fwww.appliancepartspros.com%252FAppliance-Parts%252Fwhirlpool-refrigerator-p-c--board-kit-item-number-ap3137510.aspx%253Fpn_%253D4389102&RD_PARM1=http&RD_PARM2=%253A%252F%252Fwww.appliancepartspros&RD_PARM3=.com%252FAppliance-Parts%252Fwhirlpool-refrigerator-p-c--board-kit-item-number-ap3137510.aspx%253Fpn_%253D4389102)

(http://appliancejunk.com/images/ordernow.gif) (http://click.linksynergy.com/fs-bin/click?id=omv7WULuxaw&subid=0&offerid=225193.1&type=10&tmpid=2111&RD_PARM0=http%253A%252F%252Fwww.appliancepartspros.com%252FAppliance-Parts%252Fwhirlpool-refrigerator-p-c--board-kit-item-number-ap3137510.aspx%253Fpn_%253D4389102&RD_PARM1=http&RD_PARM2=%253A%252F%252Fwww.appliancepartspros&RD_PARM3=.com%252FAppliance-Parts%252Fwhirlpool-refrigerator-p-c--board-kit-item-number-ap3137510.aspx%253Fpn_%253D4389102)
(http://www.appliancepartspros.com/partpic/Z3BqLjBfbXNfMjAxOTgzNC9MUFcvc290b2hwdHJhcC8%3d.jpg) (http://click.linksynergy.com/fs-bin/click?id=omv7WULuxaw&subid=0&offerid=225193.1&type=10&tmpid=2111&RD_PARM0=http%253A%252F%252Fwww.appliancepartspros.com%252FAppliance-Parts%252Fwhirlpool-refrigerator-p-c--board-kit-item-number-ap3137510.aspx%253Fpn_%253D4389102&RD_PARM1=http&RD_PARM2=%253A%252F%252Fwww.appliancepartspros&RD_PARM3=.com%252FAppliance-Parts%252Fwhirlpool-refrigerator-p-c--board-kit-item-number-ap3137510.aspx%253Fpn_%253D4389102)



Related Topics:
Top Ten Whirlpool and KitchenAid Indoor Icemaker Repair Topics (http://appliancejunk.com/forums/index.php?topic=10152.0)
2002 Whirlpool Icemaker - IDI - 3rd unit - need help (http://appliancejunk.com/forums/index.php?topic=10086.0)
Ice maker still not working? (http://appliancejunk.com/forums/index.php?topic=7426.0)
kenmore ice maker (http://appliancejunk.com/forums/index.php?topic=1602.0)
Kenmore SxS Model 106.56563400 Ice Maker Problems (http://appliancejunk.com/forums/index.php?topic=119.0)
kitchenaid (icemaker problem) wiring harden troubleshooting (http://appliancejunk.com/forums/index.php?topic=3716.0)
Whirlpool Gold Ice Maker not working- please help (http://appliancejunk.com/forums/index.php?topic=612.0)
Still making too much ice (http://appliancejunk.com/forums/index.php?topic=4227.0)
kenmore icemaker (no ice) (http://appliancejunk.com/forums/index.php?topic=7223.0)
Kenmore 106.52552100 ice maker problems (http://appliancejunk.com/forums/index.php?topic=78.0)
Whirlpool Ice Maker will not make ice (http://appliancejunk.com/forums/index.php?topic=1220.0)
Whirlpool ice maker problems (http://appliancejunk.com/forums/index.php?topic=6643.0)
Title: Re: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: Repair_man on January 24, 2013, 08:26:07 AM
What happened to the video?
Title: Re: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: AJ on January 24, 2013, 08:35:17 AM
Being this topic is from August 02, 2007 I don't really know what happen to the video.

I'm thinking it was one of the first videos I ever did and it was stored on the first server we ever had.
It probably got lost when we upgrading to a different server and/or when we started using youtube for videos.

http://www.youtube.com/appliancejunk (http://www.youtube.com/appliancejunk)

Maybe the video is on youtube now, not sure.

Well viewing some old topics myself I notice some youtube video's that were posted from other channels that no longer work either because they have been removed from Youtube. Not much I can do about that though.
Title: Re: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: wildimaginations on January 24, 2013, 09:58:53 PM
I thought the connection points T & M is what turns on the harvest motor.

T & H does what?

Title: Re: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: AJ on January 24, 2013, 10:06:12 PM
Quote
Test points T & H will verify if the bimetal thermostat is open or closed. Short T & H with an insulated piece of wire (14 ga.) to run the motor.

http://icemakerhelp.com/control-module/ (http://icemakerhelp.com/control-module/)
Title: Re: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: wildimaginations on January 25, 2013, 06:12:00 AM
Thanks!!!  I've doing this all wrong for the last 15 years.  Gee!!! The wonders of the internet.
Title: Re: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: charlenemhj on April 16, 2013, 09:31:28 PM
This sounds like what is wrong with our ice maker.  How can I view the video?
Thanks
Title: Re: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: AJ on April 16, 2013, 09:37:01 PM
This sounds like what is wrong with our ice maker.  How can I view the video?
Thanks

As asked before...

What happened to the video?

Still the same answer as before...

Being this topic is from August 02, 2007 I don't really know what happen to the video.

I'm thinking it was one of the first videos I ever did and it was stored on the first server we ever had.
It probably got lost when we upgrading to a different server and/or when we started using youtube for videos.

http://www.youtube.com/appliancejunk (http://www.youtube.com/appliancejunk)

Maybe the video is on youtube now, not sure.

Well viewing some old topics myself I notice some youtube video's that were posted from other channels that no longer work either because they have been removed from Youtube. Not much I can do about that though.

Title: Re: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: charlenemhj on April 16, 2013, 09:47:08 PM
How can you use a tv remote etc. to check the optic sensor since I can't see the video?
Thanks
Title: Re: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: AJ on April 16, 2013, 10:29:02 PM
charlenemhj, from what I recall the video showed how you could use a digital camera to "see" the infrared light as you can not directly see the IR light with the naked eye. The IR light is different then the red LED you maybe able to see.

If you need more help please start a new topic. Be sure to include the model number of your refrigerator and a description of what's wrong with your ice maker.
Title: Re: Video: How to make your Whirlpool ice maker run for testing and diagnostics
Post by: charlenemhj on April 16, 2013, 10:40:23 PM
Thank you, I will do that.